2026年02月06日 08:32:36 来源：东莞市美雅化工有限公司 >> 进入该公司展台 阅读量：6
物料安全资料表(MSDS)
1.物品名称:弹性体脱模剂 MK -CE311
Product name: elastomeric release agent MK-CE311
2.成份辨识资料：
Component identification data:
成份名称 Component name
|
,氟树脂 Fluororesin 10%,特殊离型成份 Special demoulding components 32%，助剂auxiliaries 3%，硅油 Silicone oil 55%
|
3. 物理及化学性质：Physical and chemical properties
外观 Appearance:无色透明液体 | Ph(5 % 稀释液)：7 | 折光系数 @20℃ ： 1.2 |
Colorless transparent liquid | Ph (5% dilution): 7 | Refraction coefficient @20 C: 1.2 |
味道：无刺激性气味 | 使用温度：30 ℃-180 ℃ | 密度：0.98ph |
Odor : No strong smell | Operating temperature: 30℃ -180℃ | Density: 0.98ph |
4. 危害辨识资料：Hazard identification data:
危害与效应 Hazards and effects | 1. 对皮肤接触 ：无毒性作用，经常及持续的皮肤接触可能会造成皮 肤表面失去脂肪及干燥，而导致皮肤病变及皮肤发炎。 |
1. Sk in co ntact : Non- toxicity, oft en ａnd persi stent sk in co ntact may caus e the skin to lose fat an d dry ing , and lead to skin les ions an d inflam mati on. | |
2. 对眼睛接触：造成眼睛不适，但不会伤害眼睛组织。 | |
2. Eye contact : cause eye discomfort, but will not damage the eye tissue. | |
3. 吸入：极少挥发，一般不会造成伤害。 | |
3. Inh alati on: little volatile, generally will no t cause harm . | |
4.食入：若不慎吞入或呕吐物而造成少量物进入肺部时，会造成肺 气肿或肺炎，非常低的毒性反应。 | |
4.Ing estion : if accidentally swallo wed or vomit caused a smal l amou nt of material into the lu ngs , can caus e emp hys ema or pneumo nia, toxicity is very low. |
5. 急救措施：Emergency treatment:
不同暴
露途径之
急救方法
The first aid for different exposure routes
| 1.吸入：将受侵袭影响者，移开危险区域，并施以适当的处置，以保持通 畅的呼吸，若是患者不规律的呼吸，或者是停止呼吸时，立刻施以人 工呼吸法急救。尽量使患者休息并立刻实施药物治疗。 |
2.Inhalation: remove the affected effect away from the danger zone, and proper disposal, to maintain smooth breathing, if patients with irregular breathing, or has stopped breathing, artificial respiration immediately to the emergency. To enable patients to rest and drug treatment immediately. | |
2.皮肤接触：手触之处不会留下指膜 | |
3.Skin contact: hａnd touch points will not leave a membrane. | |
3.眼睛接触：立刻以大量清水冲洗眼睛，直到刺痛感减轻为止(大约 10-15 分钟)，若是刺痛感持续时，请立刻就医。 | |
4.Eye contact: flush eyes with plenty of water immediately, until the tingling reduce far (about 10-15 minutes), if the pain persists, consult a doctor promptly. | |
4.食入：千万不要引发患者呕吐，使患者休息，并立刻请医生来处理。 | |
5.Ingestion: don't cause vomiting and make the patient to rest, immediately asked the doctors to deal with. |
6. 灭火措施：Extinguishing measures:
适当的灭火材料：不易燃，可用污水处理设备进行微生物处理环保。
Suitable extinguishing material: non flammable, can use for sewage treatment equipment for microbial treatment and environmental protection.
注意事项：1、不要将水直接洒入容器内，以避免泡沫外泄(溢出) 。 2、为了保护人体及降温，可用冷水喷洒危险区域，并避免将易燃物质聚集一处。
Note: 1, do not sprinkle water directly into the container, in order to avoid bubble leak (overflow). 2, in order to protect the body and cooling, cold water can spray the danger zone, and avoid
文件名称 | 物料安全资料表(MSDS) | 制定日期 | 2017/03/01 | ||
文件编号 | ICTI039-26 | 版 本 | 1.3 | 页 次 | 2/2 |
flammable material gathered.
7. 安全储存事项：Safety storage note:
1. 保持容器开关口紧闭。
2. Keep cont ain er swit ch port clo sed .
3. 储藏在阴凉干爽的地方，不用时保持容器密封，远离高温、火源。
4. Stored in a cool dry place, keep container tightly closed when not in use,keep away from heat, fire.
5. 避免直接暴露在阳光下暴晒，避免与强氧化剂、强碱、强酸接触。
6. Avoid direct exposure in the sun, avoid contact with strong oxidizing agents, alkali, strong acid contact.
7. 将原料储存于 4〜48℃环境保存，存放时间不应超过 12 个月；保持容器封口密封。
8. Raw materials will be stored in the 4 ~ 48 ℃ environment preservation, storage time should not exceed 12 months; keep container seal.
8. 搬运时注意事项：Carry notes:
小 心轻放，装卸时避免磕碰。运输过程中要确保容器不泄漏、不倒塌、不坠落、 不损坏。
Handle with care, avo id clash when loading an d un loadin g. The trans port pro cess
to ensu re that the co ntainer does not leak, does not co llapse, did not fall, no damage.
9. 防泄漏处理 Anti leakage treatment
脱 水剂加入硬水中，会产生乳白色混浊，可用风枪吹去残留水珠。
The dehyd rating ag en t ad ding hard water, will pro duce milk whit e haze, can blow to the resid ual water with air gun.
10.废弃处理注意事项：Scrap disposal notes:
由有资格的回收商作回收处理。 Recovery processing by qualified recyclers.
11.稳定性和反应性 Stability and reactivity
禁忌物 | 无 | Taboo | non |
聚合物 | 无 | Polymer | non |
12.生态学资料 Ecological data
没用生态毒性或生态信息需要报告 No toxicity or ecological information need report.
13.毒理学资料 Toxicological data
此产品无毒性 This product is non-toxic.
14.运输信息 Transport information
在运输过程中归类为一般运输品
In the transport process classified as common substances.
危险货物编号 非易燃品 The number of dangerous goods： Nonflammable
UN 编号 | 没有 UN NO. | non |
| |
包装标志 | 没用 | Packing mark | non | |
包装 | 没用 | Package | non |
|
运输注意事项 无 Transport notes | non | |||
15.法规信息 Regulatory information
法规细节 Regulations details
其他法规 Other regulations
美国法规细节 (TSCA) 符合规定
中国法规细节 (IECS) 符合规定
American regulations details (TSCA) meet the specified
Details of Chinese regulations (IECS) meet the specified
16.其他要求 Other requirements
发行记录 /
编制日期 /
修订日期 /
Release record /
Compilation data /
Revision date /
